featured image (130)

Does A Water Pump Pulley Move Freely?

Asked by: Tomas Beier
Advertisement

A whining or groaning noise usually means that either a drive belt is loose, or the water pump pulley is bad. It may surprise your customer that a pulley could fail. It does occasionally happen. Pulleys may fail due to rust, which can cause cracking between their bolt holes.

Should a water pump pulley have play?

The water pump pulley should not have much “play” in it at all. Any side to side movement would indicate wear in the shaft bushing and likely be a leak at some point in the near future.

How easily should a water pump spin?

New water pump should be nice a tight and not spin freely. Also the rotation should be perfectly smooth. If it feels gritty, it’s bad. Bearings, like the tensioner pulley are the same.

Will a bad water pump still spin?

In most cases, the water pump is binding up, causing the pulley to stop spinning. Replacement of the water pump will fix your problem. The pulley will need to be replaced if there is damage from the belt on it. If there is no damage, then the pulley can be reused.

Can you turn a car water pump by hand?

Manually rotate the pump and make sure it rotates freely. The belt drive system works hand in hand with the water pump. … When a water pump is new, some seepage from the weep hole is normal as it takes about ten minutes of operation for the pump’s internal mechanical seal to properly seat itself (break-in period).

How much does it cost to replace a water pump pulley?

The average water pump replacement cost is $550, with prices ranging from $461 to $638 in the US in 2020. But typically depends on the type of vehicle you drive and the auto repair shop you take it to. Labor costs are between $256 and $324 while parts cost between $205 and $314. Estimate doesn’t include fees and taxes.

Is the water pump pulley supposed to wiggle?

If the pulley is loose it can cause the water pump belts to shake and develop more heat. … If it’s discovered that the water pump or serpentine belt is wearing out sooner than it should, it’s likely a problem with the water pump pulley.

Can a bad water pump pulley rattle?

Rattling Noise

Worn out bearings are the most common cause of water pump failure. Water pumps move a huge amount of coolant over time, and they simply wear out. Ask your customer if they loosened a belt tensioner and checked both the tensioner(s) and water pump. Belt tensioners can also rattle when they are worn out.

What does a bad water pump on a car sound like?

Loud sounds coming from the engine are an alarm bell for car trouble. If you hear a high-pitched, whining sound that increases as you accelerate – it could indicate a faulty water pump. These sounds are caused by a loose belt and the belt becomes loose when the pulley is loose or the bearings are wearing out.

How long can you drive a car with a bad water pump?

Water pumps don’t “break” and start leaking; they have things called “weep holes”, so that when the bearings are starting to wear down, it will slowly start to drip, that way you know its time to replace it. If that is all that is happening, you’re fine to drive it for a week or so.

What noise does a bad pulley make?

When the tensioner or tensioner pulley fails, the loss of tension can cause the belt and pulleys to make high-pitched rattling or chirping noises. If the pulley bearing completely fails, it can also cause a squealing or even a grinding noise.

Advertisement

Is the AC pulley supposed to spin?

At all times, the compressor pulley should spin. … The magnetic clutch mechanism allows the compressor to pressurize the freon when it engauges.

Can you drive a car with a bad water pump?

Heating and cooling may be affected by the vehicle. The car may begin to overheat as well. It is possible to drive your vehicle without a water pump, but not good to. Some people in the racing circuit or who drive racing vehicles purposefully remove their water pumps to obtain more horsepower to their engine.

Can a bad water pump cause rough idle?

Can a bad water pump cause rough idle? Yes. Due to the effects of a bad or damaged water pump like engine Overheating and leaking coolant, your engine will experience rough idle.

Why is my water pump pulley squealing?

Failing Water Pump Pulley: The most common cause of squealing or squeaking from the timing belt cover is the water pump pulley. If the bearings in the pulley are beginning to fail, they will make noise. Eventually, they’ll seize and the water pump will no longer operate, causing your engine to overheat.

What causes a water pump to go bad?

Contaminated coolant, non-compatible coolant, or mixing coolants of different chemistries leads to premature water pump failure. Harmful contamination is common in systems that are not properly maintained. … The coolant should be entirely replaced with the correct vehicle manufacturer’s recommended coolant.

Can you change the water pump without changing the timing belt?

Yes you can replace the water pump without replacing the serpentine belt. … You will have to remove the belt to replace the water pump anyway. Since you are likely going to have to purchase a new pump, we do recommend that you purchase a belt at the same time.

How long does it take to change a water pump and timing belt?

How long does a timing belt and water pump replacement take? The average time taken for a water pump and timing belt change is between 3 to 6 hours.

Will Stop Leak fix water pump?

The liquid stop-leak product poured into the radiator will flow to the water pump seal and possibly seal or slow the leak. … Stop-leak products are not a permanent solution and will only serve as a temporary fix.

Can I change my water pump myself?

The location of the water pump in relation to the engine can vary by application. Whether you can replace it yourself depends on how much experience you have. … However, a person who easily figures out how to do things can usually replace a water pump that is on the front of the engine, without any mechanical experience.

Can a water pump be repaired?

Once the bearings fail inside the water pump, it means the unit cannot be repaired and will need to be replaced entirely. If you notice that there is a loud whining sound coming from the front of your motor that increases in volume as you accelerate, contact a mechanic as soon as possible to inspect your vehicle.

Advertisement